Occupational Safety and Health Standards: Toxic and Hazardous Substances, Air contaminants.

If you are the victim of construction accidents, use this page to conduct research. To have your case evaluated immediately, please fill out our form. Read more about the Occupational Safety and Health Standards, 1910.1, Toxic and Hazardous Substances, Air contaminants..

An employee's exposure to any substance listed in Tables Z-1, Z-2, or Z-3 of this section shall be limited in accordance with the requirements of the following paragraphs of this section.

1910.1000(a)

"Table Z-1."

1910.1000(a)(1)

"Substances with limits preceded by "C" - Ceiling Values." An employee's exposure to any substance in Table Z-1, the exposure limit of which is preceded by a "C", shall at no time exceed the exposure limit given for that substance. If instantaneous monitoring is not feasible, then the ceiling shall be assessed as a 15-minute time weighted average exposure which shall not be exceeded at any time during the working day.

1910.1000(a)(2)

"Other substances" - "8-hour Time Weighted Averages." An employee's exposure to any substance in Table Z-1, the exposure limit of which is not preceded by a "C", shall not exceed the 8-hour Time Weighted Average given for that substance any 8-hour work shift of a 40-hour work week.

1910.1000(b)

"Table Z-2." An employee's exposure to any substance listed in Table Z-2 shall not exceed the exposure limits specified as follows:

1910.1000(b)(1)

"8-hour time weighted averages." An employee's exposure to any substance listed in Table Z-2, in any 8-hour work shift of a 40-hour work week, shall not exceed the 8-hour time weighted average limit given for that substance in Table Z-2.

..1910.1000(b)(2)

1910.1000(b)(2)

"Acceptable ceiling concentrations." An employee's exposure to a substance listed in Table Z-2 shall not exceed at any time during an 8-hour shift the acceptable ceiling concentration limit given for the substance in the table, except for a time period, and up to a concentration not exceeding the maximum duration and concentration allowed in the column under "acceptable maximum peak above the acceptable ceiling concentration for an 8-hour shift".

1910.1000(b)(3)

"Example." During an 8-hour work shift, an employee may be exposed to a concentration of Substance A (with a 10 ppm TWA, 25 ppm ceiling and 50 ppm peak) above 25 ppm (but never above 50 ppm) only for a maximum period of 10 minutes. Such exposure must be compensated by exposures to concentrations less than 10 ppm so that the cumulative exposure for the entire 8-hour work shift does not exceed a weighted average of 10 ppm.

1910.1000(c)

"Table Z-3." An employee's exposure to any substance listed in Table Z-3, in any 8-hour work shift of a 40-hour work week, shall not exceed the 8-hour time weighted average limit given for that substance in the table.

1910.1000(d)

"Computation formulae." The computation formula which shall apply to employee exposure to more than one substance for which 8-hour time weighted averages are listed in subpart Z of 29 CFR Part 1910 in order to determine whether an employee is exposed over the regulatory limit is as follows:

1910.1000(d)(1)

1910.1000(d)(1)(i)

The cumulative exposure for an 8-hour work shift shall be computed as follows:

(E = C(a)T(a) + C(b)T(b) + . . . C(n)T(n)) divided by 8

Where:

E is the equivalent exposure for the working shift.

C is the concentration during any period of time T where the

concentration remains constant.

T is the duration in hours of the exposure at the concentration C.

The value of E shall not exceed the 8-hour time weighted average

specified in Subpart Z or 29 CFR Part 1910 for the substance

involved.

..1910.1000(d)(1)(ii)

1910.1000(d)(1)(ii)

To illustrate the formula prescribed in paragraph (d)(1)(i) of this section, assume that Substance A has an 8-hour time weighted average limit of 100 ppm noted in Table Z-1. Assume that an employee is subject to the following exposure:

Two hours exposure at 150 ppm

Two hours exposure at 75 ppm

Four hours exposure at 50 ppm

Substituting this information in the formula, we have

(2 X 150 + 2 X 75 + 4 X 50) divided by 8 = 81.25 ppm

Since 81.25 ppm is less than 100 ppm, the 8-hour time weighted

average limit, the exposure is acceptable.

1910.1000(d)(2)

1910.1000(d)(2)(i)

in case of a mixture of air contaminants an employer shall compute the equivalent exposure as follows:

E(m) = (C(1) divided by L(1) + C(2) divided by L(2)) + . . .

(C(n) divided by L(n))

Where:

E(m) is the equivalent exposure for the mixture.

C is the concentration of a particular contaminant.

L is the exposure limit for that substance specified in Subpart Z of

29 CFR Part 1910.

The value of E(m) shall not exceed unity (1).

1910.1000(d)(2)(ii)

To illustrate the formula prescribed in paragraph (d)(2)(i) of this section, consider the following exposures:

________________________________________________

| |

| Actual |

| concentration |

Substance | of 8-hour | 8 hour TWA

| exposure | PEL (ppm)

| (ppm) |

_____________|_______________|__________________

| |

B............| 500 | 1,000

C............| 45 | 200

D............| 40 | 200

_____________|_______________|__________________

Substituting in the formula, we have:

E(m) = 500 divided by 1,000 + 45 divided by 200 + 40 divided

by 200

E(m) = 0.500 + 0.225 + 0.200

E(m) = 0.925

Since E(m) is less than unity (1), the exposure combination is within

acceptable limits.

1910.1000(e)

To achieve compliance with paragraphs (a) through (d) of this section, administrative or engineering controls must first be determined and implemented whenever feasible. When such controls are not feasible to achieve full compliance, protective equipment or any other protective measures shall be used to keep the exposure of employees to air contaminants within the limits prescribed in this section. Any equipment and/or technical measures used for this purpose must be approved for each particular use by a competent industrial hygienist or other technically qualified person. Whenever respirators are used, their use shall comply with 1910.134.

1910.1000(f)

Effective dates. The exposure limits specified have been in effect with the method of compliance specified in paragraph (e) of this section since May 29, 1971.

Act now! It is essential that you inquire about your case as soon as possible. Litigation may be the only way to receive the damages to which you may be entitled, such as medical and health care bills, lost or diminished wages, and financial compensation to family in the case of death. Your individual state's law may limit your time to bring a legal claim to protect your rights. You need to have your construction accidents claim evaluated immediately!

Click To Talk To Us Online

see also:

OSHA Regulations FREE construction accidents OSHA information: Asbestos.
OSHA Standards: Toxic and Hazardous Substances: Asbestos

TABLE Z-3 Mineral Dusts FREE construction accidents OSHA information: TABLE Z-3 Mineral Dusts
construction accidents info: Toxic and Hazardous Substances, TABLE Z-3 Mineral Dusts

Authority for 1910 Subpart Z FREE construction accidents OSHA information: Authority for 1910 Subpart Z
construction accidents info: Toxic and Hazardous Substances, Authority for 1910 Subpart Z